021705astmtgpres

AST Stakeholder Meeting: 

AST Stakeholder Meeting California Air Resources Board Stakeholder Meeting February 17, 2005 1927 13th Street, Room 202 10:00 a.m. - 12:00 p.m.

AST Stakeholder Meeting: 

AST Stakeholder Meeting Agenda Welcome and Introductions Overview of AP-42 emission estimation approach Discuss the comments received by stakeholders Results from small scale studies Future Plans Contact Information

AST Stakeholder Meeting: 

AST Stakeholder Meeting Welcome and Introductions

AST Stakeholder Meeting: 

AST Stakeholder Meeting Overview of AP-42 Emission Estimation Approach

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach Purpose: Use AP-42 approach to calculate statewide emission estimate for Aboveground Storage Tanks (ASTs)

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach Statewide Emission Estimate For ASTs: Sum of emissions calculated for 16 regions in CA. Emissions from each region are calculated based on the tank size and configuration. Emissions = Tank Population x Emission Factor

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach Tank Population: Number of tanks in a region by size, type, and vapor recovery configuration. Determined from a statewide survey of fuel haulers.

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach Survey Status: Contacted 187 companies 62 companies responded Extrapolated results determined the presence of approximately 9,300 tanks statewide Survey portion is completed

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach Emission Factor: It is an estimated amount of hydrocarbon emissions emitted into the atmosphere in a given period of time. Calculated on a monthly basis.

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach AP-42 Methodology: Developed by American Petroleum Institute (API) Is approved by the U.S. EPA Widely used by industry Calculates Total losses/emissions from ASTs Emissions = Standing Storage or Breathing Loss + Working Loss Applies only to tanks vented through small orifices or pressure relief valves.

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach Standing Storage or Breathing Loss (Ls) It is a loss due to evaporation. Heating of the tank by the sun causes the fuel to volatilize and vent to the atmosphere. LS = nVVWVKEKS Please review pages 2 - 5 of the AP-42 document

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach Working Loss (Lw) : This loss occurs when mass of vapors are emitted to the atmosphere during the: Transfer of gasoline from cargo tank to AST (Deliveries) Transfer of gasoline from AST to vehicle (Dispenses) Lw = Lw(Deliveries) + Lw(Dispenses) Please review pages 6 and 7 of the AP-42 document.

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach Sacramento Case Study Used AP-42 methodology to calculate emission factors for 751 - 1000 gallon tank with various configurations. Intend to apply this calculation methodology to different tank sizes and configurations for all 16 regions in California. Methodology uses reasonable assumptions.

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach Assumptions Used: Tank is half full on average. Fuel surface temperature range is derived from the ambient temperature range. Phase I or Phase II vapor recovery controls Tanks with controls have a P/V valve at 2” WC Tanks without controls have no P/V valve Working loss emissions assumes 2 deliveries per year and 95% control for both Phase I and Phase II vapor recovery systems.

AP-42 Emission Estimation Approach: 

AP-42 Emission Estimation Approach

Comments Received: 

Comments Received Approach seems reasonable. Deliveries for some styles of tanks may be greater than two per year. Assumption of no P/V valves for tanks with no Phase I or Phase II controls needs to be investigated. Additional comments?

Small Scale Studies(AP-42 Bias): 

Small Scale Studies (AP-42 Bias) How well does AP-42 predict actual emissions from open tanks? Web search found two AST studies that measured emissions from open tanks without pressure relief valves. ARB performed some initial observations on small one gallon tanks with various vent openings.

Small Scale Studies(Published Literature): 

Small Scale Studies (Published Literature) AP-42 Versus Volumetric Loss (Summer Monthly Loss for a 1200 L Tank, No Pressure Relief Valve)

Small Scale Study(ARB Initial Observations): 

Small Scale Study (ARB Initial Observations) AP-42 Versus Gravimetric Measurement (16 Degree F Temperature Increase)

Small Scale Study: 

Small Scale Study Conclusions: AP-42 method significantly under estimates emissions on open systems without pressure relief valves. Need to refine method to measure emissions from open systems.

Future Plans: 

Future Plans AP-42 Correlation Study on 50 gallon AST Control Technology Demonstration Using Two Identical 50 gallon ASTs One AST will serve as a control. Second AST will be retrofitted with control technology. Emission reductions will be incrementally measured with a carbon canister.

Need Volunteers: 

Need Volunteers We need volunteers to give us access to their full size AST, so further correlation studies can be done.

Contact Information: 

Contact Information General AST Information Joe Guerrero (916) 324-9487 - jguerrer@arb.ca.gov Stephanie Connelly (916) 445-9308 - saconnel@arb.ca.gov Tank Population Ranjit Bhullar (916) 322-0223 - rbhullar@arb.ca.gov LaMar Mitchell (916) 445-9371 - lmitchel@arb.ca.gov Emission Inventory Jim Watson (916) 327-1282 - jwatson@arb.ca.gov Pamela Gupta (916) 324-4458 - pgupta@arb.ca.gov

Contact Information: 

Contact Information Need More Information? ARB Vapor Recovery Website: www.arb.ca.gov/vapor/vapor.htm ARB Aboveground Storage Tank Website: www.arb.ca.gov/vapor/ast/ast.htm